|
A1 September 20, 9:10am-9:55am
电子工业洁净室空调特点
Characteristic of the Clean Room Air Conditioning System for Electronic Industry |
|
演讲人
Speaker：周志刚，副总工程师、高级工程师
上海电子工程设计研究院有限公司
Zhou Zhigang, Vice Chief Engineer, Senior Engineer
Shanghai Electronics Engineering Design & Research Institute Co., Ltd |
发言内容摘要
各行各业的洁净空调系统都有各自的特点。电子行业洁净空调系统的特点是生产工艺变化很快。冷热负荷量变化也很快。洁净区域内发湿量非常小。洁净区域内湿湿度基础偏低。精度要求偏高。由于上述特点，因此对空调箱、制冷机、气流组织防火等的要求也具有特点。
Characteristic of the Clean Room Air Conditioning System for Electronic Industry. The Clean Room Air Conditioning System is special via different industry. The characteristic of the Air Conditioning System for electronic industry is that it changes fast according to the fast development of the process and procedure. The humidity is low and the precision is related high. With the characteristic above, there are also special requests on fire resistant for the AHU, chiller and air flow, etc. |
| |
B5 September 21, 14:00pm-15:00pm
电子工厂洁净厂房节能设计探讨
Research of Energy Saving of Electronic ClearnRoom |
Shanghai Electronics Engineering Design & Research Institute Co., Ltd.
由于电子工厂洁净厂房的特点，造成洁净空调系统设计的耗能也特别大。因此节能的空调也显得很大，很重要，可采取的节能措施途径进行探讨很有意义。
Research of the Power Saving of the Electronic Clean Room. As the characteristic of the electronic clean room, its air conditioning system could consume a lot of power. So the power saving for the system is turn to be important. It would be useful to study the power saving solution. |
| |
发言者简介
上海电子工程设计研究院有限公司副总工程师、高级工程师。现任ASHRAE协会高级会员；上海市电子学会洁净技术委员会理事；上海市技术信息交流网理事；上海制冷学会空调热泵专业委员会委员。
从事电子工业暖通、空调和专业设计30余年，曾获得国家级、部级、市级优秀工程设计奖多项；历年来，曾多次参加国家、地方及行业设计规范、标准的编制工作；多年来发表的主要论文有《水蓄冷技术在工程设计中的应用》、《开闭式循环水系统浊度的危害及对策》、《浅论冷冻循环水二次泵变频》、《电子工业洁净空调特点》。
Vice Chief Engineer, Senior Engineer of SEEDRI. Member of ASHRAE Committee, Director of Clean Room Technology Committee, Director of Shanghai Tech Information Exchange Net, Member of Shanghai Refrigeration of Association, Heat Pump Major.
Expert for HVAC for electronic industry, with 30 years experience of design. Been honored with the awards from the states, ministerial and municipal levels. Has been participated in the organizing of the code for the state, ministerial and municipal. Professional thesis published: 《Application for the Technique of Chilled Water Storage System in the Design》, 《Problem and Solution for the Turbidity of open/closed Circulating pump system》, 《Brief introduction of Verified Frequency for Secondary Pump for Circulating Cooling Water》, 《Characteristic of Clean Room for Electronic Industry》. |
| |
|
